finishing – Page 10 – Warped for Good

Quiet Friday: Square Dots

February 23, 2018February 22, 2018 Karen

It was six weeks ago that I began winding the warp for these towels. The thread for my next Glimåkra Standard project is due to arrive tomorrow. Just like I like it—revolving door weaving. I have no doubt that this set of towels will become family favorites. They are a feast for the eyes, and a tactile delight for the hands. Seeing the color on the reverse side takes my breath away. This whole experience has been the weaving satisfaction that I’ve come to cherish!

"Square Dot" towels. Satin dräll. Karen Isenhower — Square Dot towels. Ten shafts, ten treadles. Two block five-shaft satin dräll. 8/2 cotton warp. Weft is 8/2 cotton and 22/2 cottolin, and 16/2 linen for the white stripes on the red towel.

I did face difficulties near the end of the warp. The shed started deteriorating with some of the shafts, but I was determined to finish off the last towel to its full length. That meant coaxing the low profile shuttle through for a few inches. Consequently, I did have more errant floats to repair than usual. But, isn’t it wonderful that we can fix just about anything in this weaving adventure?

Fixing floats on a towel that was at the end of the warp. — End of warp. What I didn’t see at the loom is that one shaft in particular was not behaving. There were at least eight floats along that one warp end. After repairs and washing and pressing, the errors are barely noticeable.

I made a warp from thread on leftover quills to weave up some hanging tabs on my band loom for three of the towels. And I found a linen piece in my “band stash” that is perfect for the red and white towel.

Enjoy the slideshow that I made for you with details of the process.

May you weave some family favorites.

Happy Weaving,
Karen

Quiet Friday: Linen Satin Dräll

January 26, 2018January 25, 2018 Karen

This is one of those weaving projects that puts you on top of the world. Everything about it. Linen, ten shafts, five-shaft satin weave, ten treadles, gorgeous Moberg damask shuttle, single-shuttle rhythm, full-body weaving, magical fabric. I did have more than my share of knots in the warp, and a few skipped threads and selvedge loops. But you will see no evidence of those glitches now. All you will see is the natural beauty of linen, with its characteristic unevenness. And the reflective satin dräll weave, with its light-catching trickery.

The warp is Bockens unbleached 16/2 line linen. Two of the towels use 16/1 golden bleached linen for the weft. At my husband’s request, the remaining three towels have 16/2 linen weft, in ecru. The thicker weft helps make these into robust absorbent handtowels. A table square finishes off the set.

Enjoy the process with me as I reminisce over the start-to-finish pleasure of weaving these towels.

May you find pleasure in what you do.

Happy Weaving,
Karen

What to Do about Weaving Errors

January 23, 2018January 22, 2018 Karen

I’ve been waiting for a bright sunshiny day to thoroughly examine this tightly-woven linen satin dräll fabric. Today is perfect. Fixing errors must be done before the fabric is washed, when the weave will become even tighter. I am looking for unwanted floats where the shuttle skipped threads, and for loops at the selvedges.

In my examination I did find an errant float and a few small selvedge loops. Let’s get started.

Tools:

Blunt-tip needle. Sharp needle tip has been sanded to a rounded tip.

Thread. Use the same weft or warp thread that is in the area needing repair.
Good lighting. If the fabric has a complex structure, good lighting is essential.
Magnification. I take a photo on my iPhone, and then zoom in to see the minute details.

How to Mend Skipped Threads:

1 Locate the error. Here is a long weft float.

2 Thread the blunt-tip needle with a length of the same thread as the float.

3 Following the exact under-over pattern of the weave, start one inch before the float and needle-weave toward the float. I lay my iPhone nearby, with the magnified iPhone photo clearly showing the weave pattern.

4 Needle-weave the correct path of the thread through the float area. Continue needle-weaving along the same thread pathway, going one inch beyond the float.

5 Check the front and back of the fabric to see if your stitches match the correct pattern of the weave.

6 When you are certain that the float thread has been accurately replaced, clip the float and remove it (or, leave it and trim it after washing). Leave two-inch tails on the replacement thread, and trim after wet finishing. (I leave the replacement tails so I can find and check the repair after it is washed. This also allows for shrinkage before trimming.)

How to Fix a Small Selvedge Loop

1 Locate the loop.

2 Using the blunt-tip needle, gently ease the excess thread to spread over four or five stitches inside the selvedge.

3 The thread that has been eased in (just above the needle) will completely smooth out in wet finishing.

What skipped threads and loops would be found if I were examined this closely? Would I leave them and hope no one notices? Or, would I allow re-weaving and cutting away? A negative attitude is replaced with a thread of thankfulness. A loop of complaining is eased back in. The result is joy. A thankful heart knows joy. When the fabric is washed, the errant floats and loops are gone. What remains is the woven fabric with lustrous threads of joy.

May you have a bright sunshiny day.

With you,
Karen

Beauty in Cutting Off

January 12, 2018January 11, 2018 Karen

There is beauty in cut threads. They signify completion. Look what has become of these linen threads! Order and sequence, timing and continuity, perseverance and pursuit. Through a weaver’s hands it all adds up to fabric made for a purpose.

Cutting off! Linen threads flow through the reed like a waterfall. — Cutting off! Linen warp ends flow through the reed like a waterfall after the cloth is cut off.

Linen 5-shaft damask. Cutting off! — Cut threads appear as tidy fringe on the stately linen satin damask weave. The warp beam holds the cloth until it is ceremoniously unrolled.

Linen damask weaving, just cut from the loom. — Fabric and warping slats fall to the ground.

Linen fabric just off the loom, ready for finishing. — On the sewing room work table, the completed fabric awaits the finishing process. I will look for and repair errors, secure cut ends with serger stitching, and wet finish the fabric. Then, I will hem them so they can be used as the towels I envisioned from the start.

Father. With God as our Father, we are on the receiving end of the process. Grace and peace, granted from the Father’s hand, shape our lives. And, like a good weaver, our Father makes something beautiful from the threads we offer him. Imagine the day when it may be said of us, “Look what became of the linen threads in the Grand Weaver’s hands!”

May your threads turn into something beautiful.

With joy,
Karen

Share the Joy of Weaving

December 26, 2017December 25, 2017 Karen

What a delight to share the weaving experience with a friend! Two of these hot pads were woven by friends with no prior weaving experience. Miniature rag rugs make great hot pads, and provide a perfect learning experience for a guest weaver.

Rag rug hot pads. — Tenth hot pad, woven on 12/9 cotton warp. Fabric strips, previously cut for rag rugs, are used for the weft.

Ten rag rug hot pads are cut from the loom! — Ten hot pads are cut from the loom.

Finished handwoven rag rug hot pads. — Ends are tied in overhand knots and trimmed. Ready to be used!

I hope you are finding opportunities to share your joys with friends. The Christmas season reminds us that we have someone greater who shared His joy with us. He stays by our side, waiting for any call for help, but allows us to make the mistakes that teach us life lessons. As with weaving, every error can be forgiven. There is a remedy for any hopeless situation. Take courage, God is a rescuer. He sent Jesus on a mission to rescue us. And absolutely nothing can stop the mission of God. I am amazed at what he can do with the threads of a willing soul. Joy to the world, the Lord has come. Let earth receive her King.

May you share your joy.

Merry Christ – mas,
Karen